Part 1 (right chamber)
WARNING: This page does not describe the selected car, but rather 15 other vehicles, including the 2008 Audi S4, 2008 Audi RS 4, 2008 Audi A4, 2007 Audi S4, and 2007 Audi RS 4. However, it is still accessible from the selected car via links, so may be relevant.
1 - Fuel Level Sensor G
- Clipped onto baffle housing in fuel tank
- Resistance values, checking → Fuel Level Sensor G , checking
- Removing and installing → Fuel Level Sensor G , removing and installing
2 - Fuel delivery unit
- Different versions, allocation
- Can only be replaced together with flange
- Fuel pump electrical, checking → Fuel pump electrical, checking
- Checking residual pressure →
- 24 MULTIPORT FUEL INJECTION (MFI) for 1.8 LITER 4-CYL. 5V TURBO FUEL INJECTION & IGNITION, ENGINE CODE(S): AMB
- 24 - MULTIPORT FUEL INJECTION (MFI) for 2.0 LITER 4-CYL. 4V TURBO FUEL INJECTION IGNITION, ENGINE CODE(S): BPG, BWT
- 24 MULTIPORT FUEL INJECTION (MFI) for 3.0 LITER 6-CYL. 5V FUEL INJECTION & IGNITION, ENGINE CODE(S): AVK, BGN
- 24 - FUEL INJECTION SYSTEM for 3.2 V6 4V FUEL INJECTION IGNITION, ENGINE CODE(S): BKH
- 24 - MULTIPORT FUEL INJECTION (MFI) for 4.2 LITER V8 4V FUEL INJECTION AND IGNITION, ENGINE CODE(S): BNS
- 24 MULTIPORT FUEL INJECTION (MFI) for 4.2 LITER V8 5V FUEL INJECTION AND IGNITION, ENGINE CODE(S): BHF
- Removing and installing → Fuel delivery unit, removing and installing
3 - Electrical harness connector
- For Fuel level sensor G
- For Transfer Fuel Pump (FP) G6
4 - Locking flange
- For fuel delivery unit
- Cannot be replaced separately
- Installed location → Figure
5 - Seal
- Replace
- Install dry
6 - Locking ring
- Use wrench T10202 to remove and install
- Tighten to 145 Nm
7 - Fuel line
- To fuel filter
- To disconnect, press release button on connection piece
- Do not kink
- Clipped in on fuel tank
8 - Distribution piece
- Different versions, allocation
- Clipped in on baffle housing with catches
- To remove, press toward right so that catches disengage and lift upward
9 - Suction jet pipe
- To suction jet pump in baffle housing
10 - Suction jet pipe
- From left locking flange
11 - Fuel delivery line
- From suction jet pump, left side
12 - Baffle housing
- With suction jet pump