Convertible top emergency release

WARNING: This page does not describe the selected car, but rather 14 other vehicles, including the 2009 Audi S4, 2009 Audi A4, 2008 Audi S4, 2008 Audi RS 4, and 2008 Audi A4. However, it is still accessible from the selected car via links, so may be relevant.

NOTE:

If the convertible top cannot be operated because of implausible reasons, it may be in an undefined position (for the control module). Pull bracket up as far as stop and operate switch.

Convertible top compartment cover, unlocking and locking

Fig 1: Convertible Top Emergency Release Key In Basic Position

GW00020591

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Convertible top emergency release key in basic position - arrow -.

Fig 2: Convertible Top Emergency Release Key In Work Position

GW00020592

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Convertible top emergency release key in work position - arrow -.

NOTE:

Convertible top emergency release key is located at left under instrument panel fuse cover.
The designation "NES" is used for the convertible top emergency release key in the following description.

Fig 3: Lowering Side Windows

GW00020593

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Lower side windows approx. 20 cm.
Close luggage compartment cover.

Fig 4: Opening Drivers Door And Removing Fuse Carrier Cover On Instrument Panel

GW00020594

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Open drivers door and remove fuse carrier cover on instrument panel.

There is a groove on the lower edge of the fuse cover in which a screwdriver, for example, can be inserted - arrow - in order to raise.

Fig 5: Removing "NES" From Bracket Over Fuse Carrier In Instrument Panel

GW00020595

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Remove "NES" from bracket over fuse carrier in instrument panel.

Fig 6: Removing Center Piece Of Rear Backrest By Pushing Small Tabs Town Slightly And Pulling

GW00020596

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Remove center piece of rear backrest by pushing small tabs town slightly and pulling.

Fig 7: Pressing Grip Holes Together And Folding Cover Up

GW00020597

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Press grip holes together and fold cover up.
Press ski sack down and remove if necessary.

Fig 8: Inserting "NES" In Opening At Top Center Of Ski Sack Tunnel

GW00020598

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Bring "NES" into basic position as follows:

Turn red grip piece left as far as stop.
Insert "NES" in opening at top center of ski sack tunnel.

Fig 9: Turning Entire "NES" Until Small Tabs On Key Head Engage In A Groove

GW00020599

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Turn entire "NES" until small tabs on key head engage in a groove.
Turn entire "NES" ¹ /₄ turn clockwise against stop in lock.

Fig 10: Turning Red Grip Clockwise (1.5 Turns) Until Both Grip Recesses On "NES" Audibly Engage

GW00020600

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Turn red grip clockwise (1.5 turns) until both grip recesses on the "NES" audibly engage.

The "NES" is secured in the lock system and can be operated.

Fig 11: Opening Convertible Top Compartment Cover By Turning "NES" Counter-Clockwise As Far As Stop

GW00020601

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Open convertible top compartment cover by turning "NES" counter-clockwise as far as stop.

Fig 12: Pulling Convertible Top Compartment Cover Out As Far As Stop

GW00020602

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Pull convertible top compartment cover out as far as stop.

The convertible top compartment cover engages in open position.

Raise convertible top out of compartment by pulling roof edge up forcefully.

Bring convertible top into center position manually as follows:

Close convertible top until it stays half closed by itself. Slide roof edge forward as far as possible.
Raise convertible top bracket until it stays in vertical position.
Carefully press convertible top compartment cover shut.
Turn entire "NES" clockwise as far as stop.

The convertible top compartment cover is locked.

Fig 13: Removing "NES"

GW00020603

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Remove "NES" as follows:

Turn red grip piece counter-clockwise as far as stop.
Turn entire "NES" ¹ /₄ turn counter-clockwise and pull it down.

Fig 14: Convertible Top, Unlocking And Locking

GW00020604

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Convertible top, unlocking and locking

Press bracket onto convertible top compartment cover.
Press convertible top at front of vehicle onto upper windshield frame.

The convertible top may spring out slightly.

Remove cover in center of the front rail trim inside vehicle.

Fig 15: Bringing "NES" Into Basic Position

GW00020605

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Bring "NES" into basic position as follows:

Turn red grip piece left as far as stop.
Insert "NES" in opening in center of front rail trim.
Turn entire "NES" until small tabs on key head engage in a groove.
Turn entire "NES" ¹ /₄ turn clockwise against stop in lock.

Fig 16: Turning Red Grip Clockwise (1.5 Turns) Until Both Grip Recesses On "NES" Audibly Engage

GW00020606

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Turn red grip clockwise (1.5 turns) until both grip recesses on the "NES" audibly engage.

The "NES" is secured in the lock system and can be operated.

Fig 17: Turning Entire "NES" Clockwise As Far As Stop

GW00020607

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Turn entire "NES" clockwise as far as stop.
Pull convertible top down using "NES".
Turn entire "NES" counter-clockwise as far as stop.

The convertible top is locked.

Fig 18: Removing "NES"

GW00020608

Courtesy of VOLKSWAGEN UNITED STATES, INC.

Remove "NES" as follows:

Turn red grip piece counter-clockwise as far as stop.
Turn entire "NES" ¹ /₄ turn counter-clockwise and pull it down.
Re-install cover cap.
Close side windows.