LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2016 >> S4 Premium Plus, Standard Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 1301 (Mechanical Components - Brake System (Cabriolet)) >> 46 Mechanical Components >> Front Brakes >> Overview - Front Brakes >> Overview - Front Brakes, 1LM >> Overview

Overview - Front Brakes, 1LM: Overview

WARNING: This page does not describe the selected car, but rather 19 other vehicles, including the 2017 Audi S5, 2017 Audi A5 Quattro, 2016 Audi S5, 2016 Audi A5 Quattro, and 2015 Audi S5. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Exploded View Of Front Brakes, 1LM
GWWA46-10160Courtesy of AUDI OF AMERICA, LLC
  1. Bolt
    • 5 Nm 
      NOTE:

      Clean Bolts Before Reusing

      Replace Damaged Bolts

      Always replace self-locking bolts.

  2. Brake Rotor
  3. Cover Plate Bolt
    • 10 Nm 
  4. Cover Plate
  5. Stub Axle Carrier
    NOTE:

    Attach the brake hose bracket and brake pad wear indicator wire on the stub axle carrier. Bracket bolt 9 Nm 

  6. Speed Sensor
    • Removing and installing.
  7. Bolt
    • 9 Nm 
      NOTE:

      Clean Bolts Before Reusing

      Replace Damaged Bolts

      Always replace self-locking bolts.

  8. Brake Hose
    NOTE:

    Brake Hose In Brake Caliper: 16 Nm. 

    Brake Pressure Line To Brake Hose: 16 Nm. 

  9. Brake Piston
  10. Guide Pin
  11. Brake Hose Guide
  12. Brake Pad Spring
    • Two installed in every brake caliper
    • ensure installation position is correct.
  13. Brake Caliper Bolt
    • 196 Nm. 
      NOTE:

      Clean Bolts Before Reusing

      Replace Damaged Bolts

      Always replace self-locking bolts.

  14. Brake Caliper
    • When working on the brake caliper, do not let it hang by the brake hose, but secure it to the body with suitable cable ties or wire.
    • Except for "Brake Pads, Removing and Installing" and "Front Brake Caliper, Servicing", no further repairs should made to the brake caliper.
    • Hose must be installed free of twists
      NOTE:

      Bleed the brake caliper at both bleed screws.

      Bleed Screw Tightening Specification:15 Nm. 

      NOTE:

      No repairs may be performed on the brake caliper.

    • Refer to BRAKE CALIPER, REMOVING AND INSTALLING, 1LM 
    • Refer to BRAKE CALIPER, REPLACING, 1LM 
  15. Brake Pads
    • Four Installed In Each Front Brake Caliper
      WARNING:

      Four brake pads are installed per side. Only the inner, upper brake pad in the left brake caliper has a connection to the brake pad wear indicator.

    • The backing plate of the brake pads are equipped with an adhesive film. Remove the protective film from the adhesive surface before inserting.
    • Always Replace On Both Axles.
    • Refer to BRAKE PADS, REMOVING AND INSTALLING, 1LM 
    • Check the brake pad thickness. Refer to appropriate service information.
      NOTE:

      Before installing new brake pads, thoroughly clean the brake calipers of contaminants (grease-free). When doing so, pay particular attention to removing any remaining adhesive foil on outer brake pad contact surfaces.

NOTE:

Close The Bleed Screw And Tighten To 14 Nm.