LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2015 >> S3 Premium Plus >> Repair and Diagnosis >> External Pages >> Different car >> Section 82 (ENGINE ASSEMBLY [4-Cylinder Direct Injection 1.8L; 2.0L 4V TFSI Engine] -- (A3)) >> 10 Engine Assembly >> Engine, Removing And Installing >> Engine, Removing >> Vehicles With Dual-Clutch Transmission 0D9:

Vehicles With Dual-Clutch Transmission 0D9:

WARNING: This page is about a different car, the 2016 Audi A3 and 2015 Audi A3. However, it is still accessible from the selected car via links, so may be relevant.
GWWA10-11689Courtesy of AUDI OF AMERICA, LLC

-- Remove the selector lever cable from the transmission and pull it out of the cable bracket. Refer to SELECTOR MECHANISM [For transmission(s) 0GC]SELECTOR MECHANISM [For transmission(s) 0D9] .

-- Disconnect the connector -2-.

-- Push the B+ terminal protector -1- back and disconnect the B+ wire from the starter solenoid switch.

-- Remove the nut -3- and remove the ground wire.

NOTE:

Depending on the version, the ground wire is secured on the starter bolt.

CAUTION:

There is a risk of destroying the control module (Mechatronic) with static discharge.

  • Do not touch connector terminals in the transmission connector with hands.

-- To discharge static electricity, touch a ground by hand (without gloves).

-- Disconnect the connector -4- for the Dual-Clutch Transmission Mechatronic -J743-, by turning the twist lock counter-clockwise.

-- Remove the bolts -2- for the transmission (about two turns).

GWWA37-0653Courtesy of AUDI OF AMERICA, LLC

Continuation for All Vehicles:

GWWN10-0437Courtesy of AUDI OF AMERICA, LLC

-- Loosen the bolts -arrows- for the engine mount approximately two turns.

-- Loosen the hose clamp -1-, remove the air duct hose from the charge air cooler.

GWWA21-10488Courtesy of AUDI OF AMERICA, LLC

-- Disconnect the connector -1- for the radiator fan, to do this push the clip in direction of -arrow A- and push the retainer downward.

GWWA19-11279Courtesy of AUDI OF AMERICA, LLC

-- Press the left and right fan shroud locking tabs at the same time in direction of -arrow B- and remove the fan shroud downward from the radiator.

-- Loosen the hose clamp -2-.

GWWA21-10610Courtesy of AUDI OF AMERICA, LLC

-- Free up the coolant hose -3-.

-- Remove the bolts -arrows-.

-- Disconnect the connector -1- on the Charge Air Pressure Sensor -G31-.

-- Remove the right air duct pipe.

Vehicles with Parking Heater:

GWWA82-10137Courtesy of AUDI OF AMERICA, LLC

-- Loosen the clamp -1-, remove the bolt -2- and remove the parking heater muffler.

Continuation for All Vehicles:

GWWA13-10904Courtesy of AUDI OF AMERICA, LLC
NOTE:

Risk of destroying by reversing the running direction on a used ribbed belt.

Before removing the ribbed belt, mark the running direction with chalk or a felt-tip pen for reinstallation.

-- Pivot the tensioner clockwise in direction of -arrow- to release the tension on the ribbed belt.

-- Remove the ribbed belt from the A/C compressor ribbed belt pulley and release the tension on the tensioner.

-- Disconnect the connector -1- from the A/C Compressor Regulator Valve -N280-.

GWWA87-10480Courtesy of AUDI OF AMERICA, LLC
WARNING:

Refrigerant can cause serious injury.

  • Do not open the A/C system refrigerant circuit.

-- Remove the bolts -arrows-.

CAUTION:

There is a risk of damaging the A/C compressor, the refrigerant lines and hoses.

  • Do not bend, twist or stretch the refrigerant lines and hoses.

-- Remove the A/C compressor from the bracket with the refrigerant hoses connected and tie up to the right side.

AWD Vehicles: 

GWWA34-10415Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolts -arrows- and remove the right drive axle heat shield.

-- Remove the bolts -arrows- and remove the heat shield -1-.

GWWA34-11071Courtesy of AUDI OF AMERICA, LLC

-- Mark the position of flexible disc and the bevel box flange to each other for reinstallation.

GWWA10-10247Courtesy of AUDI OF AMERICA, LLC

-- Using a lever to counterhold the triangular flange, remove the driveshaft from the bevel box -arrows-.

-- Press the engine/transmission assembly slightly forward (toward the front end) and remove the driveshaft from the bevel box.

GWWV39-1817Courtesy of AUDI OF AMERICA, LLC
CAUTION:

Risk of damaging the gasket -arrow- in the driveshaft flange.

  • Press driveshaft horizontally as far back and to the left side of the vehicle as possible.
NOTE:

If the gasket is damaged, the driveshaft must be replaced.

Continuation for All Vehicles:

GWWA40-10359Courtesy of AUDI OF AMERICA, LLC

-- Remove the left and right drive axles -arrow- from the flange shafts. Refer to DRIVE AXLE .

-- Tie up the drive axles to the rear.

NOTE:

Be careful not to damage the protective coating on the drive axle.

-- Loosen the clamping sleeve -arrow- and push it toward the rear.

GWWA26-11377Courtesy of AUDI OF AMERICA, LLC

-- Remove the catalytic converter with the front exhaust pipe.

-- Remove bolt -arrow- and push the bracket for the wiring harness to the side.

GWWA10-11632Courtesy of AUDI OF AMERICA, LLC

-- Attach the :T10359/3  on the :T10359A  , as shown.

GWWA10-11633Courtesy of AUDI OF AMERICA, LLC

-- Tighten the :T10359/2  onto the engine bracket with the securing element -1- from the :3282  .

-- If necessary remove the After-Run Coolant Pump V51. Refer to After-Run Coolant Pump -V51-, REMOVING AND INSTALLING - LAYING UNDERNEATH .

-- Attach the :T10359A  with the bolt -1- to 20 Nm on the cylinder block and secure with the support element -2- from the :3282  .

GWWA10-11332Courtesy of AUDI OF AMERICA, LLC

-- Place the :VAG1383A  on the :T10359A  and raise the engine/transmission assembly slightly.

NOTE:

Use a step ladder to remove the subframe mount bolts.

GWWN10-0437Courtesy of AUDI OF AMERICA, LLC

-- Completely remove the engine mount bolts -arrows-.

NOTE:

The illustration shows a vehicle with dual-clutch transmission 0CW.

GWWA10-10949Courtesy of AUDI OF AMERICA, LLC

-- Completely remove the transmission mount bolts -arrows- completely.

NOTE:

Depending on the transmission 2 or 3 bolts.

CAUTION:

Risk of damaging the vacuum lines or wires as well as the engine compartment.

  • Make sure all the vacuum lines or wires between the engine, the transmission and the vehicle body are loosened.
  • Carefully lower and guide the engine/transmission assembly out of the engine compartment.

-- Lower the engine/transmission assembly.