Temperature Doors In The Left And Right Radiator Housing
On the "Convenience" A/C system, the front right temperature doors -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER RIGHT TEMPERATURE DOOR and the front left -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER LEFT TEMPERATURE DOOR are each actuated by an actuator (Right Temperature Door Motor -V159- and Left Temperature Door Motor -V158-). Both temperature doors for the right rear vents -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER RIGHT TEMPERATURE DOOR and the left rear -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER LEFT TEMPERATURE DOOR are connected to each other by a connecting rod; they are actuated via the Rear Temperature Door Motor -V137-. Refer to OVERVIEW - ATTACHMENTS FOR HEATER AND A/C UNIT AND AIR INTAKE HOUSING .
On the "Basis" A/C system, the temperature door for the right instrument panel vents -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER RIGHT TEMPERATURE DOOR and the front and rear right footwell vents -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER RIGHT TEMPERATURE DOOR as well as the temperature door for the left instrument panel vents -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER LEFT TEMPERATURE DOOR and the front and rear left footwell vents -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER LEFT TEMPERATURE DOOR are connected to each other by the shafts (-item ) AIR INTAKE AND OUTLET OPENINGS - LOWER TEMPERATURE DOOR SHAFT and -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER TEMPERATURE DOOR SHAFT). The right -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER RIGHT TEMPERATURE DOOR and left -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER LEFT TEMPERATURE DOOR temperature door shafts are connected to each other by a connecting rod; they are both actuated by the Temperature Regulator Door Motor -V68-. Refer to OVERVIEW - ATTACHMENTS FOR HEATER AND A/C UNIT AND AIR INTAKE HOUSING .
- Upper Right Temperature Door
- On the "Convenience" A/C system, for the right and center instrument panel vents as well as the front right footwell vent
- On the "Basis" A/C system, for the right and center instrument panel vents
- In this illustration, the temperature door is shown in the "heat" position.NOTE:
The "Basis" A/C system does not have separating walls, therefore, air does not get diffused after it has left the Auxiliary Heater Heating Element -Z35- /honeycomb.
- Upper Left Temperature Door
- On the "Convenience" A/C system, for the left and left center instrument panel vents as well as for the front left footwell vent
- On the "Basis" A/C system, for the left and center instrument panel vents -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER RIGHT TEMPERATURE DOOR.
- In this illustration, the temperature door is shown in the "cooling" position.
- Lower Right Temperature Door
- On the "Convenience" A/C system, for the rear right footwell vents
- On the "Basis" A/C system, for the front right and rear right footwell vents -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER RIGHT TEMPERATURE DOOR.
- In this illustration, the temperature door is shown in the "cooling" position.
- Lower Left Temperature Door
- On the "Convenience" A/C system, for the rear left footwell vents
- On the "Basis" A/C system, for the left front and the left rear footwell vents -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER RIGHT TEMPERATURE DOOR.
- In this illustration, the temperature door is shown in the "heat" position.
- Right Radiator Housing
- Different versions, depending on the A/C system version ("Convenience" and "Basis").
- Left Radiator Housing
- Different versions, depending on the A/C system version ("Convenience" and "Basis").
- Heat Exchanger
- Covered with different foam seals, depending on the A/C system version ("Convenience" and "Basis"). Refer to HEATER CORE, REMOVING AND INSTALLING .
- Foam Seal
- Only on vehicles equipped with the "Convenience" A/C system; present to separate the air flow between the right and left side
- Foam Seal
- Only on vehicle equipped with the "Convenience" A/C system; equipped to separate the air flow between the front and rear
- Auxiliary Heater Heating Element -Z35- /Honeycomb
- Covered with different foam seals, depending on the A/C system version ("Convenience" and "Basis"). Refer to AUXILIARY HEATER HEATING ELEMENT -Z35-, REMOVING AND INSTALLING
.NOTE:
In MY 2009, as a running change, a new version of the Auxiliary Heater Heating Element -Z35- is being installed (the heating elements are a bit more narrow); be sure to use the correct version and note the allocation. Refer to the Parts Information..
- Covered with different foam seals, depending on the A/C system version ("Convenience" and "Basis"). Refer to AUXILIARY HEATER HEATING ELEMENT -Z35-, REMOVING AND INSTALLING
.
- Foam Seal
- Only on vehicles equipped with the "Convenience" A/C system; present to separate the air flow between the right and left side
- Upper Temperature Door Shaft
- on the "Basis" A/C system, connected with the shaft -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER TEMPERATURE DOOR SHAFT (the doors move together).
- Lower Temperature Door Shaft
- on the "Basis" A/C system, connected with the shaft -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER TEMPERATURE DOOR SHAFT (the doors move together).
- Upper Temperature Door Shaft
- On the "Convenience" A/C system, located in the shaft -item ) AIR INTAKE AND OUTLET OPENINGS - LOWER TEMPERATURE DOOR SHAFT (the doors move independent of each other).
- Lower Temperature Door Shaft
- On the "Convenience" A/C system, located in the shaft -item ) AIR INTAKE AND OUTLET OPENINGS - UPPER TEMPERATURE DOOR SHAFT (the doors move independent of each other).