General Description - Refrigerant Circuit Components: Evaporator

WARNING: This page does not describe the selected car, but rather 23 other vehicles, including the 2017 Audi S5, 2017 Audi A5 Quattro, 2016 Audi S5, 2016 Audi A5 Quattro, and 2015 Audi S5. However, it is still accessible from the selected car via links, so may be relevant.

The evaporator is available in different versions. Depending on the design and the function, the heat energy of the flowing air needed (for example, an evaporator in the heater and A/C Unit or in the battery cooling module) or flowing coolant needed (for example near the high-voltage battery heat exchanger) is extracted for refrigerant evaporation. Refer to The Appropriate Service Information OVERVIEW - EVAPORATOR HOUSING / EVAPORATOR, REMOVING AND INSTALLING (REFRIGERANT CIRCUIT - 1 , REFRIGERANT CIRCUIT - 2 , REFRIGERANT CIRCUIT 1234yf - 2 , REFRIGERANT CIRCUIT GENERAL INFORMATION R134a , REFRIGERANT CIRCUIT R134a )EVAPORATOR, CLEANING .

NOTE:

Two Versions Of The Evaporator Are Described.

Evaporator in the Heater and A/C Unit (or in the Battery Cooling Module)

The liquid refrigerant evaporates in the evaporator pipe -A-. The heat required for this is extracted from the air flowing on the evaporator ribbing -B-. The air cools off. Refrigerant evaporates and is extracted with the absorbed heat by the A/C compressor

Courtesy of AUDI OF AMERICA, LLC
A definite quantity or refrigerant is supplied to the evaporator through an expansion valve (a restrictor). In systems with an expansion valve, the flow rate is regulated so that only gaseous refrigerant escapes the evaporator outlet.
With the introduction of the refrigerant R1234yf the evaporator is adapted to the refrigerant, for this reason pay attention to the version. Refer to the Parts Information.

Evaporator/High-Voltage Battery Heat Exchanger (Chiller)

The liquid refrigerant evaporates in the evaporator (heat exchanger). The heat required for this is extracted from the flowing coolant in the evaporator. The coolant cools, the refrigerant evaporates and is extracted with the absorbed heat by the A/C compressor.

Courtesy of AUDI OF AMERICA, LLC

A defined amount of refrigerant is supplied to the evaporator by a restrictor (or expansion valve) and a shut off valve. The flow rate of the refrigerant (or the coolant) is regulated so that only gaseous refrigerant escapes the evaporator outlet. Refer to CONDENSATION WATER DRAIN, REMOVING AND INSTALLING / EXPANSION VALVE WITH HYBRID BATTERY REFRIGERANT SHUT-OFF VALVE 2 -N517 and HYBRID BATTERY REFRIGERANT SHUT-OFF VALVE 1 -N516-, REMOVING AND INSTALLING .