LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2011 >> TT Base, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 20 (Rear Final Drive 02D, 0AV, 0BR, 0BS & 0BY (Coupe)) >> 39 Final Drive, Differential >> Removal And Installation >> Right And Left Flange Shaft Seals, Rear Final Drive Installed

Right And Left Flange Shaft Seals, Rear Final Drive Installed

WARNING: This page is about a different variant/trim than selected.

Special tools and workshop equipment required 

Removing 

Replacement procedure for left and right seals is identical.

-- Remove the driveshaft. Refer to "All Wheel Drive (AWD)" in Removal and Installation .

-- Place drip tray under rear final drive.

Left Flange Shaft, Removing 

Fig 1: Identifying Left Flange Shaft, Removal
GWWA39-10055Courtesy of AUDI OF AMERICA, LLC

-- Turn an M8 nut -arrow- onto the thread for the T10037.

-- Remove flange shaft with T10037.

Right Flange Shaft, Removing 

Fig 2: Identifying Right Flange Shaft, Removing
GWWA39-10054Courtesy of AUDI OF AMERICA, LLC

-- Turn an M8 nut -arrow- onto the thread for the T10037.

-- Remove flange shaft with T10037.

Procedure for Both Sides 

-- Pry off flange shaft seal using VW 681.

Fig 3: Identifying Flange Shaft Seal Pried Off With An Extractor Lever VW 681
GWWA39-10056Courtesy of AUDI OF AMERICA, LLC

Installing 

Fig 4: Identifying Thrust Piece T10049
GWWA39-10057Courtesy of AUDI OF AMERICA, LLC

-- Lightly lubricate outer diameter of new seal and install it all the way using the T10049. Be careful not to tilt it.

-- Fill the space between the sealing- and dust lip half way with sealing grease G 052 128 A1.

-- Clamp the flange shaft in a vise with jaw protectors.

Fig 5: Clamping Flange Shaft In Vise With Jaw Protectors
GWWV34-2005Courtesy of AUDI OF AMERICA, LLC

-- Use the new circlip -A- to press the previous circlip out of the flange shaft groove.

-- Install the flange shaft using a plastic hammer and a drift.

-- Install the drive axle on the flange shaft. Refer to "All Wheel Drive (AWD)" in Removal and Installation .

-- Axle oil level in rear final drive, checking. Refer to REAR FINAL DRIVE IDENTIFICATION .