Overview - Headlamp, Hid Headlamps Through My 2012

Fig 1: Exploded View Of Headlamp, HID Headlamps (Through MY 2012)

Courtesy of AUDI OF AMERICA, LLC

1. Bolt
   • 4.5 Nm 
2. Turn Signal Bulb
   • Left Front Turn Signal Bulb -M5-
   • Right Front Turn Signal Bulb -M7-
   • 12 V, 21 W (H21W)
   • Bulb, replacing, refer to LEFT/RIGHT FRONT TURN SIGNAL BULB -M5- / -M7-, REMOVING AND INSTALLING, HID HEADLAMP THROUGH MY 2012 .
3. Housing Cover
   • For the turn signal
   • For vehicles with cornering lamp
4. Seal
   • Replace if damaged.
5. Power Output Stage
   • Only for vehicles with cornering lamps
   • Left Headlamp Power Output Stage -J667-
   • Right Headlamp Power Output Stage -J668-
   • Removing and installing, refer to LEFT AND RIGHT HEADLAMP POWER OUTPUT STAGE -J667- / -J668-, REMOVING AND INSTALLING, THROUGH MY 2012 
6. Retaining Plate
   • Removing and installing, refer to LEFT AND RIGHT HEADLAMP POWER OUTPUT STAGE -J667- / -J668-, REMOVING AND INSTALLING, THROUGH MY 2012 
7. Screw
   • 1.4 Nm 
8. Housing Cover
   • For the turn signal
   • For vehicles without cornering lamp
9. Bolt
   • 1.4 Nm 
10. Daytime Running Lamp and Position Lamp LED Module
    • Left Daytime Running Lamp and Position Lamp LED Module -L176-
    • Right Daytime Running Lamp and Position Lamp LED Module -L177-
    • Removing and installing, refer to LEFT/RIGHT DAYTIME RUNNING LAMP AND POSITION LAMP LED MODULE -L176- / -L177-, REMOVING AND INSTALLING, HID HEADLAMPS THROUGH MY 2012 
11. Screw
    • 1.4 Nm 
12. HID Lamp Control Module
    • Left HID Headlamp Control Module -J343-
    • Right HID Headlamp Control Module -J344-
    • Removing and installing, refer to LEFT/RIGHT HID HEADLAMP CONTROL MODULE -J343- /J344, REMOVING AND INSTALLING, THROUGH MY 2012 
13. Seal
14. Bolt
    • 4.5 Nm 
15. Headlamp Housing Bracket
16. Screw
    • 4.5 Nm 
17. Nut
    • Self-locking
    • Replace
18. Housing Cover
    • For low beam
19. HID Headlamp Bulb
    • With integrated ignition coil
    • Left HID Headlamp Bulb -L13-
    • Right HID Headlamp Bulb -L14-
    • 42 V, 35 W (D3S)
    • Bulb, replacing, refer to LEFT/RIGHT HID HEADLAMP BULB -L13- / -L14-, REMOVING AND INSTALLING, HID HEADLAMPS THROUGH MY 2012 .
20. Adapter Wire
    • For HID headlamp bulb
    • Not available as a replacement part
21. Headlamp Housing
    • The daytime running lamps and parking lamps are LED lamps and are integrated in the headlamp housing. The LEDs cannot be replaced. The entire headlamp must be replaced.
    • The front side marker lamp bulb is an LED and is integrated in the headlamp housing. The LED cannot be replaced. The entire headlamp must be replaced.
    • Removing and installing, refer to HEADLAMP HOUSING, REMOVING AND INSTALLING, VEHICLES THROUGH MY 2012