LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2007 >> A4 Base, 2D Convertible >> Repair and Diagnosis >> Engine Mechanical >> Starter >> Electrical Equipment >> 94 Lights, Switches - Exterior >> Halogen Headlamps - through 10.04 >> High Beam Headlamp M30 / M32 - bulb, replacing

High Beam Headlamp M30 / M32 - bulb, replacing

Removing 

CAUTION:
  • Switch off all electrical consumers.
  • Switch ignition off and remove ignition key.

Left headlamp 

Fig 1: Removing Cover In Engine Compartment (Left Side)
GW00017583Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig 2: Disconnecting Electrical Connections From Retainer And Removing Retainer
GW00021643Courtesy of VOLKSWAGEN UNITED STATES, INC.

Right headlamp - vehicles with 1.8L 4-cylinder Turbo engine: 

Right headlamp - vehicles with 3.0L 6-cylinder engine: 

Fig 3: Releasing Retaining Clip And Detaching Housing Cover
GW00021644Courtesy of VOLKSWAGEN UNITED STATES, INC.

Both sides, continued: 

Fig 4: Disconnecting Electrical Connection, Releasing Retaining Clip, And Removing Bulb
GW00021645Courtesy of VOLKSWAGEN UNITED STATES, INC.

Installing 

Install in reverse order of removal, noting the following:

CAUTION:
  • Do not touch glass portion of bulb with bare hands. Even the smallest amount of moisture and/or contaminants from fingers that evaporates on the bulb during operation can cause the glass to cloud over.
  • When installing housing cover, ensure proper seating. Water intrusion will damage headlamp.
scientia non olet · About LEMON Manuals