LEMON Manuals: Even more car manuals for everyone
Home >> Acura >> 2011 >> ZDX >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> Cylinder Head >> Valve Clearance Adjustment

Valve Clearance Adjustment

NOTE: Connect the HDS to the DLC, and monitor ECT SENSOR 1. Adjust the valve clearance only when the engine coolant temperature is less than 100°F(38°C).
  1. Remove the cylinder head covers (see CYLINDER HEAD COVER REMOVAL  ).
  2. Set the No. 1 piston at top dead center (TDC). Align the pointer (A) on the front upper cover with the No. 1 piston TDC mark (B) on the front camshaft pulley.
    Fig 1: Identifying No. 1 Piston TDC Mark On Front Camshaft Pulley
    G08075089Courtesy of AMERICAN HONDA MOTOR CO., INC.
  3. Select the correct feeler gauge for the valve clearance you are going to check.

    Valve Clearance 

    Intake: 0.20-0.24 mm (0.008-0.009 in) 

    Exhaust: 0.28-0.32 mm (0.011-0.012 in) 

    REAR 

    Fig 2: Checking Rear Exhaust Valve Clearance
    G08075090Courtesy of AMERICAN HONDA MOTOR CO., INC.

    FRONT 

    Fig 3: Checking Front Intake Valve Clearance
    G08075091Courtesy of AMERICAN HONDA MOTOR CO., INC.
  4. Insert the feeler gauge (A) between the adjusting screw and the end of the valve stem on the No. 1 cylinder, and slide it back and forth; you should feel a slight amount of drag.

    INTAKE 

    Fig 4: Inserting Feeler Gauge Between Adjusting Screw And End Of Valve Stem (Intake)
    G08075092Courtesy of AMERICAN HONDA MOTOR CO., INC.

    EXHAUST 

    Fig 5: Inserting Feeler Gauge Between Adjusting Screw And End Of Valve Stem (Exhaust)
    G08075093Courtesy of AMERICAN HONDA MOTOR CO., INC.
  5. If you feel too much or too little drag, loosen the locknut, and turn the adjusting screw until the drag on the feeler gauge is correct.

    INTAKE 

    Fig 6: Loosening Locknut (Intake)
    G08075094Courtesy of AMERICAN HONDA MOTOR CO., INC.

    EXHAUST 

    Fig 7: Loosening Locknut (Exhaust)
    G08075095Courtesy of AMERICAN HONDA MOTOR CO., INC.
  6. While holding the adjusting screw with the screw driver, tighten the locknut, then recheck the clearance. Repeat the adjustment, if necessary.

    Specified Torque 

    Intake: 20 N.m (2.0 kgf.m, 15 lbf.ft) Apply new engine oil to the nut threads. 

    Exhaust: 14 N.m (1.4 kgf.m, 10 lbf.ft) Apply new engine oil to the nut threads.

  7. Rotate the crankshaft clockwise. Align the pointer (A) on the front upper cover with the No. 4 piston TDC mark (B) on the front camshaft pulley.
    Fig 8: Identifying No. 4 Piston TDC Mark On Front Camshaft Pulley
    G08075096Courtesy of AMERICAN HONDA MOTOR CO., INC.
  8. Check and, if necessary, adjust the valve clearance on the No. 4 cylinder.
  9. Rotate the crankshaft clockwise. Align the pointer (A) on the front upper cover with the No. 2 piston TDC mark (B) on the front camshaft pulley.
    Fig 9: Identifying No. 2 Piston TDC Mark On Front Camshaft Pulley
    G08075097Courtesy of AMERICAN HONDA MOTOR CO., INC.
  10. Check and, if necessary, adjust the valve clearance on the No. 2 cylinder.
  11. Rotate the crankshaft clockwise. Align the pointer (A) on the front upper cover with the No. 5 piston TDC mark (B) on the front camshaft pulley.
    Fig 10: Identifying No. 5 Piston TDC Mark On Front Camshaft Pulley
    G08075098Courtesy of AMERICAN HONDA MOTOR CO., INC.
  12. Check and, if necessary, adjust the valve clearance on the No. 5 cylinder.
  13. Rotate the crankshaft clockwise. Align the pointer (A) on the front upper cover with the No. 3 piston TDC mark (B) on the front camshaft pulley.
    Fig 11: Identifying No. 3 Piston TDC Mark On Front Camshaft Pulley
    G08075099Courtesy of AMERICAN HONDA MOTOR CO., INC.
  14. Check and, if necessary, adjust the valve clearance on the No. 3 cylinder.
  15. Rotate the crankshaft clockwise. Align the pointer (A) on the front upper cover with the No. 6 piston TDC mark (B) on the front camshaft pulley.
    Fig 12: Identifying No. 6 Piston TDC Mark On Front Camshaft Pulley
    G08075100Courtesy of AMERICAN HONDA MOTOR CO., INC.
  16. Check and, if necessary, adjust the valve clearance on the No. 6 cylinder.
  17. Install the cylinder head covers (see CYLINDER HEAD COVER INSTALLATION  ).