LEMON Manuals: Even more car manuals for everyone
Home >> Acura >> 2001 >> 3.2TL >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Instrument Panels >> System Tests >> Fuel Gauge >> 3.5RL

Fuel Gauge: 3.5RL

  1. Check No. 13 METER fuse (7.5-amp) located in underdash fuse/relay box, behind left kick panel. Check METER fuse (15-amp), located in underhood fuse/relay box. Check gauge relay located at relay box, at left front of engine compartment. See GAUGE RELAY  under COMPONENT TESTS. Remove rear seat cushion. Remove fuel tank access cover. Disconnect 3-pin fuel gauge sending unit connector.
  2. Using DVOM, check for voltage between fuel gauge sending unit 3-pin connector terminal No. 1 (Black wire) and terminal No. 2 (Blue/Green wire). Turn ignition switch to ON position. If 5-8 volts exists, go to next step. If 5-8 volts does not exist, check for poor connections or open circuit in Blue/Green wire between fuel gauge and fuel gauge sending unit. See WIRING DIAGRAMS . Check for open circuit in Black wire between fuel gauge sending unit and ground connection G652 located at left front corner of trunk. Repair as necessary.
  3. Turn ignition switch to OFF position. Connect a fused jumper wire between fuel gauge sending unit 3-pin harness connector terminals No. 1 (Black wire) and No. 2 (Blue/Green wire). Turn ignition switch to ON position. If fuel gauge pointer does not move toward "F" mark on gauge, replace fuel gauge. See INSTRUMENT CLUSTER  under REMOVAL & INSTALLATION. If fuel gauge pointer moves toward "F" mark on gauge, check fuel gauge sending unit. See FUEL GAUGE SENDING UNIT  under COMPONENT TESTS.
scientia non olet · About LEMON Manuals